sand replacement by crusher and marble powder
Partial replacement of sand with marble waste and scoria ...
2020-11-2 · At 100% combined replacement rate of sand with marble waste and scoria there is a significant reduction of a slump by 60% (30 mm) due to the significant increment of water demand at the full replacement of sand with marble waste and scoria This argument also revealed by Moreover, to easily understand the difference, the result is shown ...
Read More
Use of Waste Marble Powder as Partial Replacement in ...
2015-5-18 · But the split tensile strength decreased for the mix which contains 20 % marble powder dust against cement (10%) and sand (10%) by 11%. Hence result shows that marble powder when mixed with sand and cement together has low split strength as compared to the replacement of marble waste in cement and sand individually. 3.3 Durability.
Read More
Can Stone Powder Replace Sand? - Eastman Rock Crusher
2021-10-28 · Stone powder can not completely replace river sand but can be replaced within a certain range. Stone powder refers to particles with particle size less than 0.075mm in manufactured sand. The stone powder is the general name of stone powder. There are many kinds of stones.
Read More
river sand replacement of crusher sand - BINQ Mining
2012-11-28 · sand replacement by crusher and marble powder | Clinker sand replacement by crusher and marble powder. Use of Crushed Granite Fine as Replacement to River Sand in Concrete Production . Manasseh JOEL . »More detailed
Read More
Partial Replacement of Fine Aggregates with Quarry Dust ...
2018-6-15 · river sand. Quarry dust and Marble powder contains similar properties as that of river sand and hence accepted as a building material. The present paper focuses on investigating maximum percentage replacement of river sand by Quarry dust and Marble powder in varying equal percentages 0%, 10%, 20%, 30%, 40%, 50%, and 60% for M25 mix designations.
Read More
UTILIZATION OF WASTE QUARRY DUST AND MARBLE
2019-7-10 · incorporating marble powder as partial sand substitute. Corinaldesi et al. (2010), found that at same workability, marble powder showed high strength at 10% sand substitution. This research aims at utilization of waste marble powder and quarry dust in concrete as partial replacement of sand.
Read More
An Experimental Study on Partial Replacement of Sand
2016-3-3 · (2011) have investigated on the use of stone powder in concrete as an alternative of sand using three concrete mix proportions, 1:1.5:3, 1:2:4 and 1:2.5:5. When the results of compressive strength were compared for these mixes between use of sand and stone powder, it was found that stone powder gives higher value than sand by about 14.76%, 4% ...
Read More
Review Paper on Partial Replacement of Fine Aggregate
2018-4-20 · (normal concrete mix), three mix including lime stone waste 25%, 50% and 75% replacement from sand. Twelve mixes including lime stone waste with marble powder as additive by percent 5, 10, and 15% by weight of cement. Phase-II, the above experiment is repeated with cement content is 450 kg/ m3. Compression test at7, 28, and 90
Read More
Experimental Utilization of Marble Dust Powder as Partial ...
2018-3-13 · 20% marble powder dust as partial replacement of cement and sand together and also MX3 with 15% marble powder as partial replacement of sand, MX4 with 15% marble powder dust as partial replacement of cement and MX6 with 30% marble powder dust as partial replacement of cement and sand together. S.No. Characterist ics Specified value as per IS ...
Read More
(PDF) Comparative Study on Natural Sand and Crushed
Concrete of stone powder and brick chip gained about 10% higher strength than that of the concrete normal sand and stone chip concrete. The highest compressive strength of
Read More
Use of Waste Marble Powder as Partial Replacement in ...
2015-5-18 · But the split tensile strength decreased for the mix which contains 20 % marble powder dust against cement (10%) and sand (10%) by 11%. Hence result shows that marble powder when mixed with sand and cement together has low split strength as compared to the replacement of marble waste in cement and sand individually. 3.3 Durability.
Read More
advance in concrete technology stone dust as a
Experiment Study on Replacement of Fine. Concrete with the Partial Replacement of Cement by Marble Powder Dust and Sand by Stone Dust Md concrete technology can reduce the consumption ofConcrete technology has made significant advances the sand is partially replaced with stone dust optimum of stone dust replacement is found by observing Experiment Study on
Read More
Experimental Study On Concrete Using Waste Marble
2018-7-5 · percentage of marble powder waste is increased by 15% and by further increasing of marble powder waste compressive strength gets reduced. Test also indicates that waste marble powder can be successfully utilized as partial replacement of sand in concrete production. Their use in concrete will alleviate the problem of their
Read More
Partial Replacement of Cement with Marble Dust Powder
2016-7-1 · Partial Replacement of Cement with Marble Dust Powder. : In this project we have made fly ash cement bricks with variations in its percentage of composition. The project describes the use of local fly ash in construction industry in a way to minimize the industrial waste. The aim of this project is to find that percentage of composition by ...
Read More
Experimental Utilization of Marble Dust Powder as Partial ...
2018-3-13 · 20% marble powder dust as partial replacement of cement and sand together and also MX3 with 15% marble powder as partial replacement of sand, MX4 with 15% marble powder dust as partial replacement of cement and MX6 with 30% marble powder dust as partial replacement of cement and sand together. S.No. Characterist ics Specified value as per IS ...
Read More
Review Paper on Partial Replacement of Fine Aggregate
2018-4-20 · (normal concrete mix), three mix including lime stone waste 25%, 50% and 75% replacement from sand. Twelve mixes including lime stone waste with marble powder as additive by percent 5, 10, and 15% by weight of cement. Phase-II, the above experiment is repeated with cement content is 450 kg/ m3. Compression test at7, 28, and 90
Read More
UTILIZATION OF WASTE QUARRY DUST AND MARBLE
2019-7-10 · incorporating marble powder as partial sand substitute. Corinaldesi et al. (2010), found that at same workability, marble powder showed high strength at 10% sand substitution. This research aims at utilization of waste marble powder and quarry dust in concrete as partial replacement of sand.
Read More
An Experimental Study on Partial Replacement of Sand
2016-3-3 · (2011) have investigated on the use of stone powder in concrete as an alternative of sand using three concrete mix proportions, 1:1.5:3, 1:2:4 and 1:2.5:5. When the results of compressive strength were compared for these mixes between use of sand and stone powder, it was found that stone powder gives higher value than sand by about 14.76%, 4% ...
Read More
Chemical Composition of Cement, Sand, Crushed Dust and ...
Red mud (RM) was used as a cement substitute at five contents: 0, 2.5, 5, 7.5 and 10% in terms of weight. In addition, granite (G), limestone (LS) and marble slurry powder (MSP) were used ...
Read More
Experimental study on the behavior of waste marble
2020-8-25 · Sand and waste marble powder. Natural coarser sand was used in the current research with the fineness modulus (F.M = 3). This coarse sand was used to keep a mix balance in the gradation of aggregates because of the very fine nature of WMP. WMP was collected from Buner District, Khyber Pakhtunkhwa.
Read More
Experimental Study On Concrete Using Waste Marble
2018-7-5 · percentage of marble powder waste is increased by 15% and by further increasing of marble powder waste compressive strength gets reduced. Test also indicates that waste marble powder can be successfully utilized as partial replacement of sand in concrete production. Their use in concrete will alleviate the problem of their
Read More
UTILIZATION OF WASTE QUARRY DUST AND MARBLE
2019-7-10 · incorporating marble powder as partial sand substitute. Corinaldesi et al. (2010), found that at same workability, marble powder showed high strength at 10% sand substitution. This research aims at utilization of waste marble powder and quarry dust in concrete as partial replacement of sand.
Read More
Partial Replacement of Cement with Marble Dust Powder
2016-7-1 · Partial Replacement of Cement with Marble Dust Powder. : In this project we have made fly ash cement bricks with variations in its percentage of composition. The project describes the use of local fly ash in construction industry in a way to minimize the industrial waste. The aim of this project is to find that percentage of composition by ...
Read More
Influence of limestone waste as partial replacement ...
2012-12-1 · Twelve mixes incorporating lime stone waste 25%, 50% and 75% replacement from sand with marble powder as additive by percent 5, 10, and 15% by cement weight. Phase II, the above experiment is repeated with the same components but with different content of cement.
Read More
Experimental Utilization of Marble Dust Powder as Partial ...
2018-3-13 · 20% marble powder dust as partial replacement of cement and sand together and also MX3 with 15% marble powder as partial replacement of sand, MX4 with 15% marble powder dust as partial replacement of cement and MX6 with 30% marble powder dust as partial replacement of cement and sand together. S.No. Characterist ics Specified value as per IS ...
Read More
Review on the feasibility of Marble Dust as Replacement
2018-1-22 · waste marble powder construction industry itself as fine aggregate replacing natural sand in concrete. The replacement is done partially and fully in the proportion 0%, 25%, 50% and 100% and its effect on concrete properties were analyzed and outcomes that replacement of 50% of sand with marble powder is
Read More
Experimental study on the behavior of waste marble
2020-8-25 · Sand and waste marble powder. Natural coarser sand was used in the current research with the fineness modulus (F.M = 3). This coarse sand was used to keep a mix balance in the gradation of aggregates because of the very fine nature of WMP. WMP was collected from Buner District, Khyber Pakhtunkhwa.
Read More
Effect of Crusher Dust as Partial and Fully Replacement
2017-12-29 · Some alternative materials have already been used as a part of natural sand e.g. Fly ash, Slag lime stone and siliceous stone powder were used in concrete mixtures as a partial replacement of natural sand. On the basis, Crusher dust offers viable alternative. It is purpose made fine aggregates produced by crushing of quarried rock,
Read More
What are the Differences between Artificial Sand and ...
2020-4-18 · However, for the construction that is often subjected to frictional impact, the lime-sand ratio of the concrete, the crushing index and the stone powder content of the sand should be controlled. 5. Stone powder content. Stone powder refers to the materials with a particle size of less than 75μm mixed in the artificial sand. Generally, ordinary ...
Read More
Is high content of stone powder cause of sand making ...
二、 Content control method of machine-made sand and stone powder (1) Secondary screening: dry screening is adopted in the secondary screening workshop, and the stone powder is screened out by stone powder vibrating screen to control the content of stone powder. After screening, the stone powder less than 0.16mm can be directly packaged and ...
Read More